Osha safety checklist8/7/2023 ![]() Lights & Alarms (where present) – Functioningīattery Discharge Indicator – FunctioningĪLL OPERATORS MUST BE TRAINED AND EVALUATED ON THE TYPES OF INDUSTRIAL TRUCKS AND ATTACHMENTS THEY WILL BE OPERATING.Kitchen equipment poses special hazards to food service workers. Motor On Checks (Unusual Noises Must Be Investigated Immediately)Īccelerator Linkage – Functioning Smoothly Man-up Truck – Fall protection/Restraining means - Functioning Sitdown Truck - Seat Belt – Functioning Smoothly Hydraulic Hoses, Mast Chains, Cables & Stops – Check Visuallyīattery – Water/Electrolyte Level and ChargeĬapacity Plate Attached – Information Matches Model, Serial Number and Attachmentsīattery Restraint System – Adjust and Fasten Operator's Daily Checklist - Electric Industrial Truckįorks, Top Clip Retaining Pin and Heel - Condition Gauges: Ammeter, Engine Oil Pressure, Hour Meter, Fuel Level, Temperature, Instrument Monitors – Functioning Hoist and Lowering Control – Functioning SmoothlyĬab (if equipped) – Heater, Defroster, Wipers – Functioning Tilt Control – Forward and Back – Functioning Smoothly Steering Operation – Functioning Smoothlyĭrive Control – Forward/Reverse – Functioning Smoothly Hood Latch – Adjusted and Securely FastenedĮngine On Checks – Unusual Noises Must Be Investigated ImmediatelyĪccelerator or Direction Control Pedal – Functioning Smoothly Nameplate – Attached and Information Matches Model, Serial Number and Attachments ![]() Safety Warnings – Attached (Refer to Parts Manual for Location)īattery – Check Water/Electrolyte Level and ChargeĮngine Air Cleaner – Squeeze Rubber Dirt Trap or Check the Restriction Alarm (if equipped) Propane Tank (LP Gas Truck) – Rust Corrosion, Damage Hydraulic Hoses, Mast Chains, Cables and Stops – Check Visually ![]() ![]() Leaks – Fuel, Hydraulic Oil, Engine Oil or Radiator Coolantįorks, Top Clip Retaining Pin and Heel – Check Condition They do not include all available options, attachments or configurations. The drawings of the trucks depicted below are intended to represent the typical configuration of trucks for each type. ALL OPERATORS MUST BE TRAINED TO OPERATE ALL TYPE OF INDUSTRIAL TRUCKS THEY WILL BE OPERATING.ĭaily, pre-shift inspection of powered industrial trucks is required by OSHA standards.ĭepicted below are the major types of industrial trucks and some of the most common variations. Your workplace may have a variety of trucks that are being operated. Each of these general types has a variety of different configurations and attachments. There are two general types of powered industrial trucks: electric (battery) powered and internal combustion engine (gas/LPG/diesel) powered. The OSHA standards for powered industrial trucks must be reviewed to ensure compliance. It is recommended that the manufacturer's instructions on vehicle maintenance and owner's and operator's responsibilities also be consulted. Each type of powered industrial truck is unique and checklists pertinent to each type of vehicle should be modified accordingly. The lists serve as a guide only and may not be totally inclusive. ![]() The following checklists are being provided as part of OSHA's ongoing effort to assist employers and employees in ensuring that a safe and healthful workplace is provided. Among these topics are vehicle inspection and maintenance that the operator will be required to perform. The OSHA standard for powered industrial truck training requires that an employer provide training to truck operators on a variety of topics. OSHA wishes to acknowledge that this checklist and related graphics was developed in cooperation with the Industrial Truck Association as part of the OSHA-ITA Alliance. Department of Labor's Occupational Safety and Health Administration (OSHA). They are not a substitute for any of the provisions of the Occupational Safety and Health Act of 1970 or for any standards issued by the U.S. The following checklists are intended to assist in providing training on OSHA's powered industrial truck operator standards. Sample Daily Checklists for Powered Industrial Trucks ![]()
0 Comments
Leave a Reply.AuthorWrite something about yourself. No need to be fancy, just an overview. ArchivesCategories |